Did I misunderstand you? is this a millivolt system or 24?V system?
(is the "thermocouple" about 3/16" dia at the end, or more like a 3/8"-1/2" dia cylinder?
If it's 24V and you can get 24V to the valve, it can only be two possibities:
The valve isn't opening
The pilot safety is designed NOT to dump off the pilot, only the main, and you don't have "enough" thermocouple energy/ pilot flame
Not all valves shut off pilot gas if you "lose" the thermocouple, so to check this, shut off the gas and let the thermocouple cool, then see if you can relight the pilot. IF the pilot stays lit without the thermocouple being hot, this means that the thermocouple could STILL be the problem
If you have to wait for the thermocouple to heat before the pilot stays lit, this means that the thermocouple dumps off BOTH the pilot and the main. So if you can relight the pilot and get it to "lock on" and assuming you have 24V you can jumper to the main, then you have a bad gas valve
HOWEVER if this is a millivolt system, re--read my first post. These damn things are fussy. The thermopile can easily generate enough power to run the pilot, but not the main. IF the thermopile is going a little south OR IF the pilot is a little dirty, it may not open the main
BEFORE YOU REPLACE THE VALVE I would clean the pilot--it wants to be pretty much all blue and quiet--not blowing--and try another pile.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Tractor Profile: Oliver 70 Row Crop - by Staff. The Oliver 70 was part of the "Fleetline Series" and was manufacturered from 1937 to 1948. The row-crop configuration could have either dual or single front wheels. The Oliver 70 was also offered in the standard, orchard and industrial configurations. The tractors were sold in Canada. An early advertisement states "Power when you want it - power when you need it - power to help put in crops when field conditions are right and time and help are limited. That's the power you'll find in an Oliv
... [Read Article]
Latest Ad:
Late 50s early 60s international harvester 560 with cultivator
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
