Posted by KEH on January 05, 2008 at 06:58:32 from (209.213.26.2):
Might be a subject for discussion now that winter has come.
Some early diesel tractors, such as the 4 cyl Fergueson 35, used glow plugs. Shortly they were replaced by the 3cyl Perkins direct injection diesel which had a good reputation for starting in cold weather. Don't know if it had any other cold start aids.
Early IHC diesels started on gas, then switched to diesel after warming up. Their disadvantage was that the head design which allowed this was complicated, expensive, and probably no longer in production.
Many early diesels used a gasoline pony motor to start the diesel. Since a main part of starting a diesel is getting the motor to spin fast, the pony motor would hold up to turning the diesel better than an electric starter. Procedure for starting my cousins old D 7 Cat is to get the diesel spinning good, then spray a little ether.
Saw a neighbor start an 8000 Ford cold and it had a ether can in a fixture on the dash to inject ether.
Other Fords have a manifold heater which heats the air in the intake manifold. The Long tractor I have has this system and I have encouraged the process by using an electric heat gun to warm the manifold.
Kubotas that I am familar with use glow plugs and don't have the direct injection design. Not sure why they don't use direct injection on a farm tractor since the additional pinging noise is not such an isse on farm tractors. Some other Asian tractors use this system also.
For curiosity, I would like to know the cold start systems on later tractors, such as the 70's and 80's IHs, JDs, and ACs. I'm also curious about cold start aids on present day tractors. I'm told that some new tractors use the common rail injection system. Is cold starting any better on them?
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Search For Spares - by Anthony West (UK). Following on from the aquisition of the old Fordson F, I was very much in need of spares. As a novice though I didn't appreciate the fact that there were so many Fordson tractors made, that all the other makes seem rare by comparison. As far as I was aware a fordson was a fordson and it was only through trial an
... [Read Article]
Latest Ad:
1964 I-H 140 tractor with cultivators and sidedresser. Starts and runs good. Asking 2650. CALL RON AT 502-319-1952
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
