Posted by Destroked 450 on January 19, 2018 at 19:03:28 from (173.242.142.14):
Part of our farming operation includes 3 500 ft broiler houses.
Monday the catch crews came and loaded out all of the chickens.
Normally I start windowing the litter and cleaning equipment a day or so after the birds leave, but with the temps so low I decided to wait a fee days for the warmer temps they had forecast.The building where closed up with only a minimum ventilation fan operating on a timer.
To my surprise a little after 7:00 last night we got a alarm call from the poultry barns indicating low water levels in the well feed reservoir, this reservoir holds 40,000 gallons and the alarm is set to go off when levels drop below 20,000 gallons.
At first I thought something had happen to the well and it wasn't filling the reservoir, but the water's been shut off for 4 days so we shouldn't be using water to cause the reservoir to get low.
Jumped in the pickup and drove the 1/2 mile to the poultry barns, we have 3-4 inches of snow on the ground and as I got to the control rooms in the center of the buildings I noticed there was no snow within 2 ft of control room 2, I thought darn we've got a water leak. When I stepped out of the truck I could here water spraying and could see water running out of every crack in that little 8x10 control room plus it was pouring out a partially open door. Lucky the master valves where in control room 1 so I went there and shut off the water to building 2.
When we ship the birds out we store the feed line hoppers in the control rooms to keep them out of the weather, apparently one of the hoppers fell over and broke both water filters off causing a water leak at the rate of 30 gallons per minute, the only dry spot in that room was about 6 ft of one wall where the computers and electric panels are located, looks like we dodged a bullet on that part.
Had it not been to cold to open the buildings I would have been there working and possibly caught the leak before over 20,000 gallons of water had been pumped out.
Spent most of the day working with a cow that wouldn't accept her new born calf, but while putting out hay for the cattle I drove the tractor down to the reservoir and checked, It's full again, well pump's working fine.
Tomorrow I'll start cleaning and will add plumbing in new water filters to the repair list.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Women and Tractors - More Views From the Farmer's Wife - by Teri Burkholder. The top ten reasons why the judges wouldn't let you participate in the stock antique tractor pull: Hey, this is stock! It came with that V8 in it! That "R" on my tires stands for "really old" not radial! Blue gas? We thought it was a pretty color! What wire hooked to my throttle?
... [Read Article]
Latest Ad:
Sell 1958 Hi-Altitude Massey Fergerson tractor, original condition. three point hitch pto engine, Runs well, photos available upon request
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
