Posted by Mrfix71 on April 30, 2013 at 03:41:52 from (96.35.250.161):
Hopefully, this post finds itself in the proper forum area:
This year, my tractor (IH-454 with C-157 engine) will not stay running at high idle or PTO speed. After operating for a few minutes it will randomly lug way down and die but if I am quick, I can shut off the PTO and idle down for a few seconds then slowly bring everything back up. Or, I can idle less than 1000rpm the engine will appear to run just fine indefinately. If the engine dies, I can shut off PTO and close governor control and tractor starts right up.
I originally thought I had bad gas and completely drained the system. Then, I thought it was fuel pump not providing enough fuel, but fuel flow appears to be adequate, even with a small tear in the top gasket/diaphram. While troubleshooting and observing, the governor appeared to be sticking but after complete disassembly, cleaning,checking linkage, and manipulating running governor controls, I am back to something wrong with the zenith model carb. A quick disassemble and cleaning did not reveal anything obvious.
CARB: Ever since I bought the tractor, the choke has always been in the center position and ran fine. I did verify proper operation but thought "If it ain't broke....don't fix it". Yesterday, while making idle ajustments, to my surprise turning the to mix screw did almost nothing.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - The David Brown Rose Badge - by Samuel Kennedy. In the 13th century civil war was raging in England. Two English noblemen were involved in a conflict which became known as the War of the Roses. The Duke of York had as his emblem a white rose and the Earl of Lancaster had a red rose. Today the white rose is the official emblem of the county of Yorkshire and the red rose has been adopted by the neighboring county of Lancashire.
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.