Posted by J.R.THOMAS on July 08, 2009 at 19:27:13 from (24.183.227.6):
"JD 318 SOLENOID OR FLY WHEEL". MY FIRST POSTING WAS BACK IN JAN.TELLING OF THE SOUNDS THE STARTER MAKES.WELL,IT HAS BEEN 6 MONTHS AND MY PROBLEM HAS COME TO A HEAD. I CLEANED UP WITH GUNK ENGINE CLEANER ALL AROUND THE STARTER AND THE RELAY. A WEEK LATER IT WOULDN'T START. THE BATTERY TEST BAD AND WAS 6 YEARS OLD SO I REPLACED IT. NOW THE LIGHTS ON THE DASH BURN AND THE STARTER WOULD NOT MAKE A SOUND. I TAPPED ON THE BOTTOM PART(IS THAT THE SOLENOID) AND TRIED AGAIN TO START IT . THIS TIME I COULD HEAR THE SOLENOID CLICK, BUT NO STARTER SOUND. LOOKING AT THE ENDS OF THE SOLENOID THE BIG HOT RED CABLE FROM THE BATTERY CONNECTS AND A SMALL RED WIRE GOING TO THE RELAY CONNECT TO THE BOTTOM LUG, TO THE LEFT OF THAT A PURPLE WIRE HAS A PUSH ON CONNECTOR COMING FROM THE RELAY.I GUESS THE RED WIRE ALLOWS THE CURRENT TO PASS THE RELAY WHEN IT IS MADE AND CARRY CURRENT TO THE SOLENOID, TURNING IT ON, ENGAGING THE STARTER OR THE STARTER SHIFT LEVER ENGAGES THE FLYWHEEL. IS THIS CORRECT ????????? JUST ABOVE AND TO THE RIGHT IS THE OTHER BIG LUG. THERE IS A FUNNY COPPER BRAIDED SHORT NON-INSULATED WIRE THAT IS LOOSE AND SEEMS TO GO NO WHERES. THAT IS THIS???? IS THIS A FUSE?
I REMOVED THE RELAY AND WILL REPLACE IT TOMORROW.
LOOKING THE PARTS UP AT JOHN DEERE I FIND THERE ARE TWO KINDS OF STARTERS. BENDIX TYPE AND THE SOLENOID TYPE. I THINK MINE IS THE SOLENOID TYPE. HELP! IF YOU HAVE A REPAIR MANUAL HELP! I DON'T KNOW WHERE TO START TO PULL THE ENGINE. MODEL M00318X366114 1987 ONAN B43G ENGINE
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Identifying Tractor Noises - by Curtis Von Fange. Listening To Your Tractor : Part 3 - In this series we are continuing to learn the fine art of listening to our tractor in hopes of keeping it running longer. One particularly important facet is to hear and identify the particular noises that our
... [Read Article]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.