Posted by mdeisenhauer on November 20, 2023 at 08:54:54 from (66.249.121.23):
As the subject states, I recently installed a rebuilt injector pump on my 4010 JD and it's running, but lacks significant power.
What I've done so far, previously I was having a reoccurring issue where the tractor would run for 20 mins and then die, I could prime the low pressure pump and it would run again for 20 mins and then die again. (Note, when it was running, it was running strong) With help from this forum, I was told the drive ring was deteriorating and needed to be rebuilt.
So I sent my pump to a shop in NE for rebuild. I installed it at TDC with the timing marks lined up and the oil pump arrow pointing towards the block. I bled the injectors and it started right up. But when revving the engine, it coughs and sputters like it has half the power it used to have. I've tried clocking the injector pump both directions and it's basically acting the same, low power and smoking more than it used to prior to the rebuild.
Any ideas on what I need to do to get it running right?
Upload one or more videos to your post. Photo and video filesizes should be less than 5MB. Formats allowed are gif, jpg, png, ogg, mp4, mov, and avi. Be sure to use filenames without spaces or special characters, and filetypes of 3 digits lower case.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - The Rescue of a Fordson F - by Anthony West. Introduction I live in the UK and have for many years restored Fordson tractors (in the main model N's). I have also restored and shown model F's, E 27N's, Field Marshall Series 2, David Brown Cropmasters and the old rey Fergeson T 20. At one time I had seven restored examples which were shown and used in ploughing matches. As most restorers, I have a number of war stories I can relate on a range of topics that may help other like minded and interested people. Perhaps my first p
... [Read Article]
Latest Ad:
Sell 1958 Hi-Altitude Massey Fergerson tractor, original condition. three point hitch pto engine, Runs well, photos available upon request
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.