(800) 853-2651
SHOP NOW

Deutz Gear Lube Help

J

James D Wilson

New User
I have a Deutz 4507. It is my first tractor and I know nothing about it.It has water in the rear gear housing. I pulled the plug on the very bottomand about 10 galons of mustard cream looking thick oil came out. Where do I refill it? How much of what do I put in it? Also I pulled out what looks like a big plug on top of the aux hydaulics. It has a spring under it and the fluid was a thin tan milk colored. It also seems to be part of the power steering. Where do I drain it and how do I fill it. Is the top a seperate system from the bottom? What fluids do they take?
 
Sounds like you should try to find an owners manual at least and shop manuals if possible. The owners manual will be a real moneymaker. Any chance that thing has been through a few spring floods?
Good Luck.

Dave
 
Been a little while since I worked on those, but the transmission fluid is seperate from the hydraulic fluid. The transmission was GL5 80W/90 gear oil and the hydraulics was Universal tractor oil 15W/30. The trans on most deutz tractors is pressure lubricated and there is usually a washable gauze strainer to clean. Filler/ level plug I think was on the right side of the trans and so was the strainer. The hydraulic fluid goes in the hydraulic top cover (rockshaft housing) a lot of tractors had an additional hydraulic tank to the left of the hydraulic top cover, the tanks had a level (sight glass) I think there was a black plastic cap with a dipstick on the hyraulic top cover. On later tractors the hyd oil was common to the trans oil. On some deutz tractors the rear axle oil is seperate to the trans oil but I think this was only on the bigger tractors. Hope this helps, Richard.
 
You must log in or register to reply here.

Similar threads

H
Deutz 4006 Hydraulic System
Replies
4
Views
479
used red MN
U
A
3rd and 4th gear shift not staying engaged
Replies
1
Views
118
pomester
P
super99
Transmission pressure guage
Replies
17
Views
772
Cash4Toys
C
R
Loftness Snowblower Gearbox Help Needed
Replies
4
Views
353
wore out
wore out
H
New Holland TD95D Locked in Gear
Replies
3
Views
189
Jerry/MT
J
Tractor Parts Tractor Manuals

We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today.

Copyright © 1997-2024 Yesterday's Tractor Co.

All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.

Yesterday's Tractors - Antique Tractor Headquarters
Website Accessibility Policy

Back
Top