(800) 853-2651
SHOP NOW

JD 1010 crawler Carburetor

M

Mtjohnso

Member
Have John Deere 1010 crawler with a gas engine.
Got the manual from Jen Sales. The manual has a very good
description of the Marvel-Schebler carburetor repair and
adjustments.
However this 1010 crawler has a Zenith Carburetor on it.
It runs with this carb but also is leaking gas out the bottom like
the float is stuck.
Want to rebuild the carb and fix it.
Did JD put Zenith carbs on the 1010 crawler or is this someones
modification?
I will pull the carb in another day or so and find the part number
and try to order a rebuild kit.
 
Tractor dealers and farm parts catalog places sold aftermarket/generic replacement carbs for many applications over the years and in the end Zenith Fuel Systems wound up owning Marvel Schebler.

If originality isn't an issue it shouldn't be to tough to find info on the 'net and fix what you have.
 
Well first off one need to under stand the up draft carb . The dripping gas out the bottom after shut down is somewhat NORMAL . BUT if it is a steady stream now ya have and issue . When you are first tryen to start ya pull the choke and turn the engine over if it starts like it should then ya see no gas dripping , if it does not start all that extra fuel being sucked UP now falls back down and drips out the weep hole a lot heavier . after running when ya shut the engine off the engine does not just stop dead it slows to a stop all the while still sucking gas UP and when it does stop turning and no longer sucking what goes up must come back down and ya get the DRIP , So before you dive into waters uncharted by you first make sure that this DRIP is not part of the NORMAL cycle of and up draft carb , remove the air cleaner hose and LOOK for the FLOOD if NO flood then it's fine keep fingers out .
 
You must log in or register to reply here.

Similar threads

M
Zenith carburetor
Replies
7
Views
390
ken44520978
K
M
JD 1010 dozer blade mounting plate
Replies
2
Views
396
2x4
2
M
John Deere 1010 dozer not starting
Replies
6
Views
458
Dan in Ohio
Dan in Ohio
K
Carburetor rebuild kit
Replies
13
Views
385
Geo-TH,In
Geo-TH,In
N
1010 crawler
Replies
3
Views
259
Jim.ME
J
Tractor Parts Tractor Manuals

We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today.

Copyright © 1997-2024 Yesterday's Tractor Co.

All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.

Yesterday's Tractors - Antique Tractor Headquarters
Website Accessibility Policy

Back
Top